Manitowoc SU1024YC Guia de Resolução de Problemas

Manitowoc Beverage Equipment2100 Future Drive  Sellersburg, IN 47172-1868Tel: 812.246.7000, 800.367.4233  Fax: 812.246.9922www.manitowocbeverage.com

10Installation and Service ManualINSTALLATIONICEMAKER REQUIREMENTSThe LP-3 may be equipped with a Manitowoc® SU1024YC icemaker. Refer to the Manitowoc

Installation and Service Manual11INSTALLATIONDRAINSRight Side of unit as shipped:1. During installation all drains on right side of the unitmust be pr

12Installation and Service ManualINSTALLATIONPURGE TUBE ROUTING1. During installation of the LP-3 the carbonator tankpurge tube (A) must be properly r

Installation and Service Manual13A check valve must be installed in the water supply line 3 feet from the noncarbonated water connection“PW”. Contact

14Installation and Service ManualOPERATIONUNIT INSPECTIONThoroughly inspect the unit upon delivery. Immediately report any damage that occurred during

Installation and Service Manual15OPERATIONEQUIPMENTThe LP-3 is a 10 flavor ice and beverage dispenser, withthe ice storage bin located below the count

16Installation and Service ManualOPERATIONICE STORAGE AND DISPENSINGIce is stored in the dispenser’s bin. Ice below the stainless steel bin liner is u

Installation and Service Manual17Dimensions 44.4" X 31.1" X 57.3" (including top cover)Weight 570 lbs (with ice 870 lbs)Electrical Requ

18Installation and Service ManualOPERATIONSPECIFICATIONSB-I-BThe Bag-In-Box system refers to a plastic disposable bag. The B-I-B normally contains 5 g

Installation and Service Manual191. Incoming tap water - should be at a minimum dy-namic pressure of 40 psi and maximum of 55 psi.2. Carbonator Water

20Installation and Service ManualCarbonatedwater OutletCO2InletWaterInletElectronicProbesGroundPressureReliefPurgeTubeOPERATIONCARBONATIONThe purpose

Installation and Service Manual211. Disconnect electrical power to the unit.2. Remove thumb screws holding plastic splashguards and stainless splash p

22Installation and Service ManualUSER MAINTENANCEClean the exterior, nozzles and diffusers:1. Turn off the key switch located on either right or lefts

Installation and Service Manual23USER MAINTENANCEMONTHLY CLEANINGCLEANING AND SANITIZING OF THE DISPENSERNote: Sanitize the dispenser at initial start

24Installation and Service ManualUSER MAINTENANCEBEVERAGE SYSTEM CLEANINGSanitize the beverage system at initial start-up as well as during regularly

Installation and Service Manual25USER MAINTENANCEBAG-IN-BOX SYSTEM10. Connect Bucket 3 to system.11. Draw sanitizing solution through system until sol

26Installation and Service ManualEXPLODED VIEWS, PARTS & DIAGRAMS115V WIRING DIAGRAM

Installation and Service Manual27EXPLODED VIEWS, PARTS & DIAGRAMSCOVERS & PANELSNO Part# Description1 5029883 CABINET GALV2 020000214 RH COVER

28Installation and Service ManualNo. Part Number Description1 5012090 GRID2 5012238 DRAINPAN RH3 5012311 CUBER 120VEXPLODED VIEWS, PARTS & DIAGRAM

Installation and Service Manual29EXPLODED VIEWS, PARTS & DIAGRAMSPANELS & LID BONNETNO Part Number Description1 000000246 LABEL LOGO SNOWFLAKE

FOREWORDManitowoc Beverage Equipment (MBE) developed this manual as a reference guide for the owner/operator, service agent, and installer of this eq

30Installation and Service ManualEXPLODED VIEWS, PARTS & DIAGRAMSAUGER, AGITATION & DRAIN

Installation and Service Manual31EXPLODED VIEWS, PARTS & DIAGRAMSLEGS, CARB TANK & ELECTRIC BOXNo Part Number Description 1 5029874 MNT MOTOR

32Installation and Service ManualEXPLODED VIEWS, PARTS & DIAGRAMSAUGER DRIVE, VALVE MOUNT, ROCKING CHUTE, PUMPNO. Part Number Description1 5029884

Installation and Service Manual33EXPLODED VIEWS, PARTS & DIAGRAMS120V AUGER DRIVE

34Installation and Service ManualEXPLODED VIEWS, PARTS & DIAGRAMS120V CUBERRIGHT SIDE BONNET COVER LEFT SIDE BONNET COVERNO Part # Description1 09

Installation and Service Manual35EXPLODED VIEWS, PARTS & DIAGRAMS120V CARB PUMP & TANK ASSEMBLYNo. Part Number Description1 1701110 NUT 3/8&qu

36Installation and Service ManualEXPLODED VIEWS, PARTS & DIAGRAMSAUGER & ROCKING CHUTE

Installation and Service Manual37EXPLODED VIEWS, PARTS & DIAGRAMSVALVE MOUNT CAP & AGITATOR MOTOR

38Installation and Service ManualEXPLODED VIEWS, PARTS & DIAGRAMSAUGER TRANSITION & 120V ELECTRIC BOX

Installation and Service Manual39EXPLODED VIEWS, PARTS & DIAGRAMSBIN

TABLE OF CONTENTSFOREWORD ... 3UNPACKING AND INSP

40Installation and Service ManualMANITOWOC® SU1024YC ICEMAKERCONTROL BOX & EVAPORATOR COMPARTMENTDESCRIPTION PART NUMBER1 Control Board (for use

Installation and Service Manual41MANITOWOC® SU1024YC ICEMAKERREFRIGERATION COMPARTMENT32856181917161117101214913144

42Installation and Service ManualMANITOWOC® SU1024YC ICEMAKERREFRIGERATION COMPARTMENTDESCRIPTION PART NUMBER1 Water Dump Valvea. Dump Valve Assembl

Installation and Service Manual43DESCRIPTION PART NUMBER 1 Compressor a. 208-230V/60 Hz/1 ph. . . . . . . . . . . . . . . . . . . . . . . . . . . .

44Installation and Service ManualMANITOWOC® SU1024YC ICEMAKERCVD1075 CONDENSING UNIT PANELSDESCRIPTION PART NUMBER1 Condenser Fan Guard . . . . . . .

Installation and Service Manual45TROUBLESHOOTINGPROBLEM POSSIBLE CAUSE CORRECTIVE ACTIONPump will not run buttank appears to bealways full.Black and/o

46Installation and Service ManualTROUBLESHOOTINGPROBLEM POSSIBLE CAUSE CORRECTIVE ACTIONPump motor intermittent Problem with Liquid Level ControlBoard

Installation and Service Manual47

48Installation and Service Manual

49Installation and Service Manual

USER MAINTENANCE ... 21HOW TO DISASSEMBLE FOR CLEANING OR MAINTENAN

INDEXAagitation ... 15, 16agitation cycle ... 16Agitator Motor ... 37Ambient ...

51Installation and Service Manual

Manitowoc Beverage Equipment2100 Future Drive  Sellersburg, IN 47172-1868Tel: 812.246.7000, 800.367.4233  Fax: 812.246.9922www.manitowocbeverage.com

6Installation and Service ManualWARNING: The splash panel must remain in place for installation because the splash panel pro-vides structural integrit

Installation and Service Manual7GROUNDING IN STRUCTIONSSAFETYThis appliance must be grounded. In the event of malfunction or breakdown, grounding prov

8Installation and Service ManualPost mix system: CO2 regulator set Beverage dispenser Beverage tubing CO2 tank Carbonator Stepless (Oetiker) c

Installation and Service Manual9INSTALLATIONUNIT INSTALLATIONThe LP-3 is shipped in a heavy duty corrugated carton with a wooden pallet. Inspect the u